Инструкция на 2-Post Lifts S4B-2/T4 (англ.)Страница 12 из 31
3 Oil blows out breather of power unit: A. Oil reservoir overfilled. B. Lift lowered too quickly while under a heavy load. 4 Motor hums and will not run: A. Impeller fan cover is dented. Take off and straighten. B. Faulty wiring......call electrician C. Bad capacitor......call electrician D. Low voltage......call electrician E. Lift overloaded... 5. Lift jerks going up and down: Air in hydraulic system. Raise lift all the way to top and return to floor; Repeat 4-6 times. Do not let this overheat power unit. 6 Oil leaks: A. Power unit: if the power unit leaks hydraulic oil around the tank-mounting flange; check the oil level in the tank. The level should be two inches below the flange of the tank. Check with a screwdriver. B. Rod end of the cylinder: the rod seal of the cylinder is out. Rebuild or replace the cylinder. C. Breather end of the cylinder: the piston seal of the cylinder is out. Rebuild or replace the cylinder. 7. Lift makes excessive noise: A. Leg of the lift is dry and requires grease. B. Cylinder pulley assembly or cable pulley assembly is not moving freely. C. May have excessive wear on pins or cylinder yoke. OWNER/EMPLOYER RESPONSIBILITIES The owner/employer: Shall establish procedures to periodically maintain, inspect and care for the lift in accordance with the manufactures recommended procedures to ensure it’s continued safe operations. Shall provide necessary lockout / tag outs of energy sources per ANSI Z244.1 -1982 before beginning any lift repairs. Shall not modify the lift in any manner without prior written consent of the manufacturer. Shall display the operating instructions and “Lifting It Right” and “Safety Tips” supplied with the lift in a conspicuous location in the lift area convenient to the operator. Shall insure that lift operators are instructed in the proper and safe use and operation of the lift using the manufacturer’s instructions and “Lifting It Right” and “Safety Tips” supplied with the lift. Страницы: 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 |
